升降貨梯在使用的時候，有可能會產生升降動作突然變慢的現象，遇到這種情況，我們需要及時的進行查找原因，避免發生危險，造成不必要的損失，下面就給大家詳細的解答下相關問題原因。

When the cargo elevator is in use, the lifting action may suddenly slow down. In this case, we need to find out the reasons in time to avoid danger and unnecessary losses. Here are the detailed answers to the relevant questions and reasons.

升降貨梯在升降的時候為什么會出現動作變慢的現象：

Why does the cargo elevator slow down when lifting

1、其產生的原因如下所示：

1. The causes are as follows:

升降貨梯中混入了空氣，指在油缸中混入了從而造成了執行緩慢。

Air is mixed in the cargo elevator, which means it is mixed in the oil cylinder, resulting in slow execution.

或者是升降貨梯的升降壓力調的太低了，無法升起升降貨梯。升降貨梯液壓系統磨損嚴重,工作壓力高則引起內泄漏顯著加大。

Or the lifting pressure of the elevator is too low to lift the elevator. The hydraulic system of the cargo elevator is seriously worn, and the internal leakage is significantly increased when the working pressure is high.

執行件在未帶負載時運動速度正常，一旦帶上負載速度立即下降。這些大多數原因都是在液壓上發生，當然我們也不能排除掉是電路的問題，導致了執行元件無法運動或者是運動狀態不良。

When the speed of the belt is not normal, the speed of the belt will be reduced immediately. Most of these reasons are caused by hydraulic pressure. Of course, we can't rule out the problem of circuit, which leads to the failure of actuator movement or poor movement state.

2、怎么才能避免這種現象的產生呢？

2. How can we avoid this phenomenon?

1、施工電梯人員經過正規培訓且經考試合格取證后方可上崗操作;施工人員嚴格遵守使用說明書規定操作。

1. The construction elevator personnel can work only after they have received formal training and passed the examination; The construction personnel shall operate in strict accordance with the instructions.

2、各施工范圍內的上下梯籠的通道口兩側，設置停機標志與防護欄桿。設備的導軌架上安裝梯籠上下行程限位開關。

2. Stop signs and protective railings shall be set on both sides of the access opening of the upper and lower ladder cages within each construction scope. The up and down travel limit switch of the ladder cage is installed on the guide rail frame of the equipment.

3、標準節在加節時，安裝梯籠高限位開關。做好防雷接地的保護裝置，電阻小于10歐姆。

3. When the standard section is added, the ladder cage high limit switch shall be installed. Make lightning protection and grounding protection devices with resistance less than 10 ohms.

4、應當認真定期做好日常保養工作。若在運行中發生故障時，要先排除故障方可繼續運行。施工電梯設備每個季度應進行一次完整的檢查，以杜絕設備隱患。

4. Daily maintenance shall be done carefully and regularly. If a fault occurs during operation, the fault must be eliminated before continuing operation. The construction elevator equipment shall be completely inspected once a quarter to eliminate the hidden dangers of the equipment.

升降貨梯的工作環境有哪些：

What are the working environments of the cargo elevator:

1、很多客戶使用升降平臺的需求不同，需求的類型也不一樣，如今的升降設備多種多樣，根據需求也可定制，所以，在那里使用是很不錯選擇哪種升降設備的關鍵。

1. Many customers have different needs and types of lifting platforms. Today, there are a variety of lifting equipment, which can also be customized according to their needs. Therefore, using it there is a good key to choose which lifting equipment.

2、比如：有的客戶在室內使用，要求環境整潔，不要挖地坑，并且需要防護網等，這時候就可以選擇哪種提升式升降平臺和導軌式升降平臺。

2. For example, some customers use indoors and require a clean environment, do not dig pits, and need protective nets. At this time, they can choose which lifting platform and guide rail lifting platform.

3、有的客戶選擇室外使用，對于整潔要求沒有嚴格，可以開挖地坑，也可以添加防護網，選擇挖地坑的就很多，選擇通常型的固定剪叉式升降平臺的自然增多。

3. Some customers choose to use outdoors without strict requirements for cleanliness. They can dig pits or add protective nets. Many choose to dig pits, and the number of fixed scissor lifting platforms of normal type naturally increases.

以上就是為大家介紹的有關導軌式升降平臺的詳細介紹,希望對您有所幫助.如果您有什么疑問的話,歡迎聯系我們.我們將以的態度,為您提供服務

The above is a detailed introduction to the guide rail lifting platform. I hope it will be helpful to you If you have any questions, please contact us We will provide you with professional service